Heinz Factory – Wigan

The Heinz factory at Kitt Green in Wigan produces over 1.3 billion cans of food a year, including soups, beans, pasta, infant foods and puddings.

CHALLENGE

The Heinz factory at Kitt Green in Wigan produces over 1.3 billion cans of food a year, including soups, beans, pasta, infant foods and puddings.

This huge production requires the generation of 100 tonnes of steam every hour, which is used for both space heating and sterilisation of canned foods.

The steam is produced in an energy centre which has four boilers. The energy centre replaces the existing boiler plant, which is now at the end of its operational life. Each boiler has two gas-fired burners, fitted with fans to push air into the flame.

These eight fans are controlled by eight ABB standard drives, rated 55 kW, which vary the speed of the fans to control the amount of air injected, depending on whether a high or low flame is required. This ability to vary the flame to match steam demand is expected to make the energy centre 14 percent more efficient than the existing steam plant.

Barry Aspey, Environmental Compliance Manager for Heinz, says: “I specified variable speed drives for use on the plant so we could take account of the variations in demand. We have a six day a week operation and although steam demand stays reasonably flat, it does ramp up slowly over a period of 36 hours and ramps down over a period of 24 hours. It also varies from summer to winter, when there is a greater demand for heating and we also produce more soups.”

SOLUTION

Eight ABB standard drives, each rated at 55 kW, installed on burners of steam generation plant

BENEFITS

Energy centre is 14 percent more efficient than previous boiler plant

Variable speed drives allow Heinz to take account of seasonal production demands

Variable speed drives are more responsive than mechanical dampers, which tend to introduce a time lag when demand changes direction

Similar case studies

Water and Waste

Quantum’s fast response keeps Northumbrian Water pumping

Quantum Controls took only two hours to solve a problem for Northumbrian Water (NW) when it needed to hire a

Read article
Water and Waste

Northumbrian Water to save £100,000 energy costs with ABB drives

Northumbrian Water is set to save over £100,000 a year on pump running costs following a project with ABB Dives

Read article
Water and Waste

Northumbrian Water Bran Sands

Following the installation of a Variable Speed Drive for energy saving the treatment works Anaerobic Digester, Northumbria Water have seen

Read article